Limits...
Effect of liner design, pulsator setting, and vacuum level on bovine teat tissue changes and milking characteristics as measured by ultrasonography.

Gleeson DE, O'Callaghan EJ, Rath MV - Ir Vet J (2004)

Bottom Line: Milk yield per cow was significantly (P < 0.05) higher and cluster-on time was reduced (P < 0.01) with the WB cluster as compared to the NB1 cluster.Widening pulsator ratio from 60:40 to 67:33 did not have negative effects on changes in teat tissue and had a positive effect on milk yield and milking time.Milk liner design had a bigger effect on teat tissue changes and milking characteristics than pulsation settings.

View Article: PubMed Central - HTML - PubMed

Affiliation: Teagasc, Moorepark Research Centre, Fermoy, Co Cork, Ireland. davidgleeson@eircom.net.

ABSTRACT
: Friesian-type dairy cows were milked with different machine settings to determine the effect of these settings on teat tissue reaction and on milking characteristics. Three teat-cup liner designs were used with varying upper barrel dimensions (wide-bore WB = 31.6 mm; narrow-bore NB = 21.0 mm; narrow-bore NB1 = 25.0 mm). These liners were tested with alternate and simultaneous pulsation patterns, pulsator ratios (60:40 and 67:33) and three system vacuum levels (40, 44 and 50 kPa). Teat tissue was measured using ultrasonography, before milking and directly after milking. The measurements recorded were teat canal length (TCL), teat diameter (TD), cistern diameter (CD) and teat wall thickness (TWT).Teat tissue changes were similar with a system vacuum level of either 50 kPa (mid-level) or 40 kPa (low-level). Widening the liner upper barrel bore dimension from 21.0 mm (P < 0.01) or 25.0 mm (P < 0.001) to 31.6 mm increased the magnitude of changes in TD and TWT after machine milking. Milk yield per cow was significantly (P < 0.05) higher and cluster-on time was reduced (P < 0.01) with the WB cluster as compared to the NB1 cluster. Minimum changes in teat tissue parameters were achieved with system vacuum level of 40 kPa and 50 kPa using NB and WB clusters, respectively. Similar changes in teat tissue and milk yield per cow were observed with alternate and simultaneous pulsation patterns. Widening pulsator ratio from 60:40 to 67:33 did not have negative effects on changes in teat tissue and had a positive effect on milk yield and milking time. Milk liner design had a bigger effect on teat tissue changes and milking characteristics than pulsation settings.

No MeSH data available.


Measurement of teat canal length (a), teat diameter (b), cistern diameter (c), and teat wall thickness (d).
© Copyright Policy
Related In: Results  -  Collection


getmorefigures.php?uid=PMC3113817&req=5

Figure 2: Measurement of teat canal length (a), teat diameter (b), cistern diameter (c), and teat wall thickness (d).

Mentions: The teat parameters measured included teat canal length (TCL), teat diameter (TD), cistern diameter (CD), and teat wall thickness (TWT). TD was measured across the distal end of the teat canal; CD and TWT measurements were made at 10 mm from this point (Figure 2). Teats were washed with warm running water and dried with paper towels before the pre-milking measurement.


Effect of liner design, pulsator setting, and vacuum level on bovine teat tissue changes and milking characteristics as measured by ultrasonography.

Gleeson DE, O'Callaghan EJ, Rath MV - Ir Vet J (2004)

Measurement of teat canal length (a), teat diameter (b), cistern diameter (c), and teat wall thickness (d).
© Copyright Policy
Related In: Results  -  Collection

Show All Figures
getmorefigures.php?uid=PMC3113817&req=5

Figure 2: Measurement of teat canal length (a), teat diameter (b), cistern diameter (c), and teat wall thickness (d).
Mentions: The teat parameters measured included teat canal length (TCL), teat diameter (TD), cistern diameter (CD), and teat wall thickness (TWT). TD was measured across the distal end of the teat canal; CD and TWT measurements were made at 10 mm from this point (Figure 2). Teats were washed with warm running water and dried with paper towels before the pre-milking measurement.

Bottom Line: Milk yield per cow was significantly (P < 0.05) higher and cluster-on time was reduced (P < 0.01) with the WB cluster as compared to the NB1 cluster.Widening pulsator ratio from 60:40 to 67:33 did not have negative effects on changes in teat tissue and had a positive effect on milk yield and milking time.Milk liner design had a bigger effect on teat tissue changes and milking characteristics than pulsation settings.

View Article: PubMed Central - HTML - PubMed

Affiliation: Teagasc, Moorepark Research Centre, Fermoy, Co Cork, Ireland. davidgleeson@eircom.net.

ABSTRACT
: Friesian-type dairy cows were milked with different machine settings to determine the effect of these settings on teat tissue reaction and on milking characteristics. Three teat-cup liner designs were used with varying upper barrel dimensions (wide-bore WB = 31.6 mm; narrow-bore NB = 21.0 mm; narrow-bore NB1 = 25.0 mm). These liners were tested with alternate and simultaneous pulsation patterns, pulsator ratios (60:40 and 67:33) and three system vacuum levels (40, 44 and 50 kPa). Teat tissue was measured using ultrasonography, before milking and directly after milking. The measurements recorded were teat canal length (TCL), teat diameter (TD), cistern diameter (CD) and teat wall thickness (TWT).Teat tissue changes were similar with a system vacuum level of either 50 kPa (mid-level) or 40 kPa (low-level). Widening the liner upper barrel bore dimension from 21.0 mm (P < 0.01) or 25.0 mm (P < 0.001) to 31.6 mm increased the magnitude of changes in TD and TWT after machine milking. Milk yield per cow was significantly (P < 0.05) higher and cluster-on time was reduced (P < 0.01) with the WB cluster as compared to the NB1 cluster. Minimum changes in teat tissue parameters were achieved with system vacuum level of 40 kPa and 50 kPa using NB and WB clusters, respectively. Similar changes in teat tissue and milk yield per cow were observed with alternate and simultaneous pulsation patterns. Widening pulsator ratio from 60:40 to 67:33 did not have negative effects on changes in teat tissue and had a positive effect on milk yield and milking time. Milk liner design had a bigger effect on teat tissue changes and milking characteristics than pulsation settings.

No MeSH data available.